Sani-Tred - Basement Waterproofing System

SHARE THIS PAGE:

FacebookTwitterGoogleLinkedInPinterestStumbleUponReddit

Deck Coatings

Hotel and Motel Walkways

Due to unique technical breakthroughs in polymer chemistry, a complete, permanent indoor or outdoor deck coating & waterproofing system is both available and affordable for the general public and commercial or industrial property owner! SANI-TRED systems are available in smooth seamless styles and colors or various custom slip resistant textures.

SANI-TRED is the only indoor or outdoor deck coating system with flexible penetration technologycombined with elongation memory, (the ability to be stretched and return to it's original size and shape.   Due to these and other unique qualities no other products or system can match SANI-TRED's record of success and performance in the field of negative hydrostatic pressure waterproofing.  SANI-TRED systems do not weaken with age, unlike other waterproofing products, but actually strengthens over time with higher qualities because of it's unique polymer chemistry.

SANI-TRED products maintain permanent flexibility and never harden or become brittle, they only become stronger with age. SANI-TRED Permaflex, (liquid rubber primer and top coating), penetrates deeply into the pores of the concrete substrate and produces tiny solid rubber sealing plugs. These tiny plugs or sealing tentacles in each and every pore or crack in the substrate hold back and retains water pressure before it has a chance to reach the SANI-TRED coating surface to peel it off en masse as with other types of coatings. These sealing tentacles work like tiny, high pressure, hydraulic o-rings or "flexible penetration technology™ ". The tentacles seal, anchor, and lock the coating to the concrete or mortar substrate. This is one of the main characteristic that gives SANI-TRED the ability to retain "negative hydrostatic pressure". SANI-TRED products will never detach from freeze/thaw cycles which makes SANI-TRED especially important for hotel and motel decks and walkways when combined with it's slip resistance and complete compatibility with salt brine.

The photos below show a concrete patio block which was coated on one side with SANI-TRED Permaflex which was red-tinted to allow better visual detection of the SANI-TRED microscopic penetration process. The block was then broken in half to show its internal cross section. Notice the penetration of the red Permaflex throughout the entire block.

Order Now

 

Permaflex "deep penetration,  o-ring fingers" seen here  penetrating  up to 1-1/2" deep

SANI-TRED LRB (Liquid Rubber Base), a single component, high technology, polyurethane product, has the unique ability to cure at any thickness of application without gassing and molecularly bonds to itself new-to-old without creating cold joints or weakness at the joint. These chemically unique features, when coupled with SANI-TRED Permaflex's ability to permanently penetrate and bond to concrete or other standard building materials, creates a waterproofing system which can retain almost sixty times  the amount of negative hydrostatic pressure normally found in a commercial slab-on-grade or below-grade-slab.   These are some of qualities of SANI-TRED products that sets SANI-TRED systems above any other products in the world in the field of negative hydrostatic pressure deck waterproofing. 

 Install a new 3/4" tongue and groove plywood substrate directly over the existing flat deck materials. If the existing underlying deck substrate is wood, it is extremely easy to nail down new plywood over all or a portion of the old deck materials. This can be done a little at a time or all at once at the option of the building owner. Large, poorly fitted or excessively wide seams may be quickly filled, sealed and bonded using LRB/TAV mixtures. If the flat roof deck has no parapet walls install new drip edge and seal the drip edge and all flashing, mechanicals and vent pipes with LRB/TAV mixtures instead of tar.

Flat Roof Plywood Decks

  1. Prime all joints, seams, cracks, holes and around physicals with Permaflex
  2. Install 2” fiberglass joint tape by brushing or rolling it into the wet Permaflex on all joints
  3. Caulk/fill using 3/4” LRB/TAV bead brushed or smoothed (as per above sketch.)
  4. Apply a base coat Permaflex over roof @ 240 sq ft gal
  5. Apply LRB with catalyst membrane @ 50 sq ft gal
  6. Apply surface coat AR or Permaflex-AL @ 240 sq ft gal
     

SANI-TRED systems are used as the critical primer installed before standard two part epoxies, ceramic tile, or other such rigid deck systems to protect them from detachment, blistering, or delamination due to moisture vapor drive. SANI-TRED products provide the perfect bonding platform for most flexible coatings and rigid epoxies even in high load, hard flooring specifications. The SANI-TRED priming coats perform perfectly as an impact and shock absorbing buffer which helps prevent damage to the epoxy surface coats.

Parking Decks


Residential Balconies

Resort Sun Decks

Swimming Pool Deck Repairs

Commercial Outdoor or Indoor Walkways

 

 

TESTIMONIALS

Jhon Jessen

Five years ago our basement was more of a swimming Floor then a useable basement. The walls were fieldstone with mortar. The floor was cracked in so many places that after it rained the water came up like springs!...READ MORE

Todd Brannan

My name is Todd Brannan and I ordered the basement waterproofing  system a few months ago. Thanks sanitred, now I'm setting things on the basement floor I could have never put there before. Good Product... READ MORE

Larry Piccirilli

I am totally impressed and pleasantly surprised.  I am highly recommending the Sani-tred system to my friends even if they don't have water problems.  I figure if I tell everyone about it, they will remember where to come and get the info...READ MORE

Stu Cassell

Our swimming pool was losing 2-3 inches of water a day. We had two different pool companies attempt to fix the leaks. Neither was successful...READ MORE

Wes Lukaszek

First of all, I want to thank you for your expert advice about your products. Everything worked as you said it would. Your products are very easy to work with...READ MORE

Curt Hugo

I wanted to let you know I used your product, PermaFlex and LRB/TAV on the cracks on my basement wall. I'm very impressed with the results....READ MORE